Fujitsu AOYG45KRTA Manual

Fujitsu Aircondition AOYG45KRTA

Læs gratis den danske manual til Fujitsu AOYG45KRTA (21 sider) i kategorien Aircondition. Denne vejledning er vurderet som hjælpsom af 37 personer og har en gennemsnitlig bedømmelse på 4.8 stjerner ud af 19 anmeldelser. Har du et spørgsmål om Fujitsu AOYG45KRTA, eller vil du spørge andre brugere om produktet?

Download PDF

Side 1/21

En-1

WARNING

• Installationofthisproductmustbedonebyexperiencedservicetechniciansor

professionalinstallersonlyinaccordancewiththismanual.Installationbynonprofes-

sionalorimproperinstallationoftheproductmaycauseseriousaccidentssuchas

injury,waterleakage,electricshock,orre.Iftheproductisinstalledindisregardof

theinstructionsinthismanual,itwillvoidthemanufacturer’swarranty.

• Toavoidgettinganelectricshock,nevertouchtheelectricalcomponentssoon

afterthepowersupplyhasbeenturnedo󰀨.Afterturningo󰀨thepower,alwayswait

10minutesormorebeforeyoutouchtheelectricalcomponents.

• Donotturnonthepoweruntilallworkhasbeencompleted.Turningonthepowerbe-

foretheworkiscompletedcancauseseriousaccidentssuchaselectricshockorre.

• Ifrefrigerantleakswhileworkisbeingcarriedout,ventilatethearea.Iftherefrigerant

comesincontactwithaame,itproducesatoxicgas.

• Installationmustbeperformedinaccordancewithregulations,codes,orstandards

forelectricalwiringandequipmentineachcountry,region,ortheinstallationplace.

• Donotusethisequipmentwithairoranyotherunspeciedrefrigerantintherefriger-

antlines.Excesspressurecancausearupture.

• Duringinstallation,makesurethattherefrigerantpipeisattachedrmlybeforeyou

runthecompressor.

Donotoperatethecompressorundertheconditionofrefrigerantpipingnotattached

properlywith3-wayvalveopen.Thismaycauseabnormalpressureintherefrigera-

tioncyclethatleadstoruptureandeveninjury.

• Wheninstallingorrelocatingtheairconditioner,donotmixgasesotherthanthe

speciedrefrigerant(R32)toentertherefrigerantcycle.

Ifairorothergasenterstherefrigerantcycle,thepressureinsidethecyclewillriseto

anabnormallyhighvalueandcauserupture,injury,etc.

• Toconnecttheindoorunitandoutdoorunit,useairconditionerpipingandcables

availablelocallyasstandardparts.Thismanualdescribesproperconnectionsusing

suchinstallationset.

• Donotmodifypowercable,useextensioncableorbranchwiring.Improperusemay

causeelectricshockorrebypoorconnection,insu󰀩cientinsulationorovercurrent.

• Donotpurgetheairwithrefrigerantsbutuseavacuumpumptovacuumtheinstallation.

• Thereisnotextrarefrigerantintheoutdoorunitforairpurging.

• UseavacuumpumpforR32orR410Aexclusively.

• Usingthesamevacuumpumpfordi󰀨erentrefrigerantsmaydamagethevacuum

pumportheunit.

• UseacleangaugemanifoldandcharginghoseforR32orR410Aexclusively.

• Donotusemeanstoacceleratethedefrostingprocessortoclean,otherthanthose

recommendedbythemanufacturer.

• Theapplianceshallbestoredinaroomwithoutcontinuouslyoperatingignitionsources

(forexample:openames,anoperatinggasapplianceoranoperatingelectricheater).

• Donotpierceorburn.

• Beawarethatrefrigerantsmaynotcontainanodour.

• Duringthepump-downoperation,makesurethatthecompressoristurnedo󰀨before

youremovetherefrigerantpiping.

Donotremovetheconnectionpipewhilethecompressorisinoperationwith3-way

valveopen.

Thismaycauseabnormalpressureintherefrigerationcyclethatleadstoruptureand

eveninjury.

• Thisapplianceisnotintendedforusebypersons(includingchildren)withreduced

physical,sensoryormentalcapabilities,orlackofexperienceandknowledge,unless

theyhavebeengivensupervisionorinstructionconcerninguseoftheappliancebya

personresponsiblefortheirsafety.Childrenshouldbesupervisedtoensurethatthey

donotplaywiththeappliance.

• Ifthepowercableortheconnectioncableisdamaged,itmustbereplacedbythe

manufacturer,itsserviceagentorsimilarqualiedpersonsinordertoavoidasafety

hazard.

• Keepanyrequiredventilationopeningsclearofobstruction.

CAUTION

• Fortheairconditionertoworkappropriately,installitaswritteninthismanual.

• Thisproductmustbeinstalledbyqualiedpersonnelwithacapacitycerticationof

handlingrefrigerantuids.Refertoregulationandlawsinuseoninstallationplace.

• Installtheproductbyfollowinglocalcodesandregulationsinforceattheplaceof

installation,andtheinstructionsprovidedbythemanufacturer.

• Thisproductispartofasetconstitutinganairconditioner.Theproductmustnotbe

installedaloneorbeinstalledwithnon-authorizeddevicebythemanufacturer.

• Alwaysuseaseparatepowersupplylineprotectedbyacircuitbreakeroperatingon

allwireswithadistancebetweencontactof3mmforthisproduct.

• Toprotectthepersons,ground(earth)theproductcorrectly,andusethepowercable

combinedwithanEarthLeakageCircuitBreaker(ELCB).

• Thisproductisnotexplosionproof,andthereforeshouldnotbeinstalledinexplosive

atmosphere.

• Thisproductcontainsnouser-serviceableparts.Alwaysconsultexperiencedservice

techniciansforrepairing.

• Wheninstallingpipesshorterthan3m,soundoftheoutdoorunitwillbetransferred

totheindoorunit,whichwillcauselargeoperatingsoundorsomeabnormalsound.

• Whenmovingorrelocatingtheairconditioner,consultexperiencedservicetechni-

ciansfordisconnectionandreinstallationoftheproduct.

• Donottouchthensoftheheatexchanger.Touchingtheheatexchangernscould

resultindamagetothensorpersonalinjurysuchasskinrupture.

• Anindooruniterror(errorcode:2-3)occursifanindoorunitforR410Aisconnectedto

therefrigerantsysteminaconcurrentmultipleconnectionenvironment.Inthatcase,

notetheindoormodelnamethatexperiencestheerror,andcontactourservicecentre.

AIRCONDITIONER

OUTDOORUNIT

INSTALLATION MANUAL

PARTNo.9379069960-02

1. SAFETY PRECAUTIONS

• Besuretoreadthismanualthoroughlybeforeinstallation.

• Thewarningsandprecautionsindicatedinthismanualcontainimportantinformation

pertainingtoyoursafety.Besuretoobservethem.

• Handthismanual,togetherwiththeoperationmanual,tothecustomer.Requestthe

customertokeepthemonhandforfutureuse,suchasforrelocatingorrepairingthe

unit.

WARNING

Indicatesapotentiallyorimminentlyhazardoussituation

which,ifnotavoided,couldresultindeathorseriousinjury.

CAUTION

Indicatesapotentiallyhazardoussituationthatmayresultin

minorormoderateinjuryordamagetoproperty.

[Originalinstructions] Forauthorizedservicepersonnelonly.

Contents

1. SAFETYPRECAUTIONS............................................................................1

2. PRODUCTSPECIFICATION.......................................................................3

2.1.Installationtools....................................................................................3

2.2.Accessories..........................................................................................4

2.3.Piperequirements................................................................................4

2.4.Electricalrequirements.........................................................................5

2.5.Additionalchargeamount.....................................................................5

2.6.Generalinformation..............................................................................6

3. INSTALLATIONWORK...............................................................................6

3.1.Installationdimensions.........................................................................7

3.2.Transportingtheunit.............................................................................7

3.3.Mountingtheunit..................................................................................8

3.4.Draininstallation...................................................................................8

3.5.Pipeinstallation....................................................................................8

3.6.Sealingtest.........................................................................................10

3.7.Vacuumprocess.................................................................................10

3.8.Additionalcharging............................................................................. 11

3.9.Electricalwiring................................................................................... 11

4. TESTRUN.................................................................................................14

4.1.Pre-testruncheckitems.....................................................................14

4.2.Testoperationmethod........................................................................14

4.3.Checklist.............................................................................................14

5. FINISHING.................................................................................................15

5.1.Installinginsulation.............................................................................15

5.2.Fillingwithputty..................................................................................15

6. HOWTOOPERATEDISPLAYUNIT.........................................................15

6.1.Displayunitposition............................................................................15

6.2.Descriptionofdisplayandbuttons......................................................15

7. FIELDSETTING........................................................................................16

7.1.Fieldsettingbuttons...........................................................................16

7.2.Functionsettings................................................................................16

8. EXTERNALINPUTANDOUTPUT............................................................ 17

8.1.Externalinput......................................................................................17

8.2.Externaloutput...................................................................................18

9. PUMPDOWN............................................................................................18

9.1.Preparationforpumpdown................................................................ 19

9.2.Pumpdownprocedure.......................................................................19

10. ERRORCODES........................................................................................19

10.1.Errordisplaymode...........................................................................19

10.2.Errorcodechecktable......................................................................20

EnglishDeutschFrançaisEspañolItalianoEλληvIkάPortuguêsРусский

Türkçe

En-2

2-7.Checkstotherefrigerationequipment

• Whereelectricalcomponentsarebeingchanged,theyshallbetforthepurpose

andtothecorrectspecication.

• Atalltimesthemanufacturer’smaintenanceandserviceguidelinesshallbefollowed.

• Ifindoubtconsultthemanufacturer’stechnicaldepartmentforassistance.

• Thefollowingchecksshallbeappliedtoinstallationsusingammablerefrigerants.

-Thechargesizeisinaccordancewiththeroomsizewithinwhichtherefrigerant

containingpartsareinstalled.

-Theventilationmachineryandoutletsareoperatingadequatelyandarenot

obstructed.

-Ifanindirectrefrigeratingcircuitisbeingused,thesecondarycircuitshallbe

checkedforthepresenceofrefrigerant.

-Markingtotheequipmentcontinuestobevisibleandlegible.Markingsandsigns

thatareillegibleshallbecorrected.

-Refrigerationpipeorcomponentsareinstalledinapositionwheretheyareunlikely

tobeexposedtoanysubstancewhichmaycorroderefrigerantcontainingcompo-

nents,unlessthecomponentsareconstructedofmaterialswhichareinherently

resistanttobeingcorrodedoraresuitablyprotectedagainstbeingsocorroded.

2-8.Checkstoelectricaldevices

• Repairandmaintenancetoelectricalcomponentsshallincludeinitialsafetychecks

andcomponentinspectionprocedures.

• Ifafaultexiststhatcouldcompromisesafety,thennoelectricalsupplyshallbe

connectedtothecircuituntilitissatisfactorilydealtwith.

• Ifthefaultcannotbecorrectedimmediatelybutitisnecessarytocontinueopera-

tion,anadequatetemporarysolutionshallbeused.

• Thisshallbereportedtotheowneroftheequipmentsoallpartiesareadvised.

• Initialsafetychecksshallinclude.

-Thatcapacitorsaredischarged:thisshallbedoneinasafemannertoavoid

possibilityofsparking.

-Thattherenoliveelectricalcomponentsandwiringareexposedwhilecharging,

recoveringorpurgingthesystem.

-Thatthereiscontinuityofearthbonding.

3.Repairstosealedcomponents

• Duringrepairstosealedcomponents,allelectricalsuppliesshallbedisconnected

fromtheequipmentbeingworkeduponpriortoanyremovalofsealedcovers,etc.

• Ifitisabsolutelynecessarytohaveanelectricalsupplytoequipmentduringservic-

ing,thenapermanentlyoperatingformofleakdetectionshallbelocatedatthe

mostcriticalpointtowarnofapotentiallyhazardoussituation.

• Particularattentionshallbepaidtothefollowingtoensurethatbyworkingon

electricalcomponents,thecasingisnotalteredinsuchawaythatthelevelof

protectionisa󰀨ected.

• Thisshallincludedamagetocables,excessivenumberofconnections,terminals

notmadetooriginalspecication,damagetoseals,incorrectttingofglands,etc.

• Ensurethatapparatusismountedsecurely.

• Ensurethatsealsorsealingmaterialshavenotdegradedsuchthattheynolonger

servethepurposeofpreventingtheingressofammableatmospheres.

• Replacementpartsshallbeinaccordancewiththemanufacturer’sspecications.

NOTES:Theuseofsiliconsealantmayinhibitthee󰀨ectivenessofsometypesof

leakdetectionequipment.

Intrinsicallysafecomponentsdonothavetobeisolatedpriortoworking

onthem.

4.Repairtointrinsicallysafecomponents

• Donotapplyanypermanentinductiveorcapacitanceloadstothecircuitwithout

ensuringthatthiswillnotexceedthepermissiblevoltageandcurrentpermittedfor

theequipmentinuse.

• Intrinsicallysafecomponentsaretheonlytypesthatcanbeworkedonwhilelivein

thepresenceofaammableatmosphere.

• Thetestapparatusshallbeatthecorrectrating.

• Replacecomponentsonlywithpartsspeciedbythemanufacturer.

• Otherpartsmayresultintheignitionofrefrigerantintheatmospherefromaleak.

5.Cabling

• Checkthatcablingwillnotbesubjecttowear,corrosion,excessivepressure,vibra-

tion,sharpedgesoranyotheradverseenvironmentale󰀨ects.

• Thecheckshallalsotakeintoaccountthee󰀨ectsofagingorcontinualvibration

fromsourcessuchascompressorsorfans.

6.Detectionofammablerefrigerants

• Undernocircumstancesshallpotentialsourcesofignitionbeusedinthesearching

forordetectionofrefrigerantleaks.

• Ahalidetorch(oranyotherdetectorusinganakedame)shallnotbeused.

7.Leakdetectionmethods

• Electronicleakdetectorsshallbeusedtodetectammablerefrigerants,butthe

sensitivitymaynotbeadequate,ormayneedre-calibration.(Detectionequipment

shallbecalibratedinarefrigerant-freearea.)

• Ensurethatthedetectorisnotapotentialsourceofignitionandissuitableforthe

refrigerantused.

• LeakdetectionequipmentshallbesetatapercentageoftheLFLoftherefrigerant

andshallbecalibratedtotherefrigerantemployedandtheappropriatepercentage

ofgas(25%maximum)isconrmed.

• Leakdetectionuidsaresuitableforusewithmostrefrigerantsbuttheuseof

detergentscontainingchlorineshallbeavoidedasthechlorinemayreactwiththe

refrigerantandcorrodethecopperpipe-work.

• Ifaleakissuspected,allnakedamesshallberemoved/extinguished.

• Ifaleakageofrefrigerantisfoundwhichrequiresbrazing,alloftherefrigerantshall

berecoveredfromthesystem,orisolated(bymeansofshuto󰀨valves)inapartof

thesystemremotefromtheleak.

Oxygenfreenitrogen(OFN)shallthenbepurgedthroughthesystembothbefore

andduringthebrazingprocess.

Precautions for using R32 refrigerant

Thebasicinstallationworkproceduresarethesameasconventionalrefrigerant(R410A,

R22)models.

However,paycarefulattentiontothefollowingpoints:

WARNING

• Sincetheworkingpressureis1.6timeshigherthanthatofrefrigerantR22models,

someofthepipingandinstallationandservicetoolsarespecial.(Referto

“2.1.Instal-

lationtools”.)

Especially,whenreplacingarefrigerantR22modelwithanewrefrigerantR32model,

alwaysreplacetheconventionalpipingandarenutswiththeR32andR410Apiping

andarenutsontheoutdoorunitside.

ForR32andR410A,thesamearenutontheoutdoorunitsideandpipecanbe

used.

• ModelsthatuserefrigerantR32andR410Ahaveadi󰀨erentchargingportthread

diametertopreventerroneouschargingwithrefrigerantR22andforsafety.There-

fore,checkbeforehand.[ThechargingportthreaddiameterforR32andR410Ais1/2

inch.]

• BemorecarefulthanR22sothatforeignmatter(oil,water,etc.)doesnotenterthe

piping.

Also,whenstoringthepiping,securelysealtheopeningbypinching,taping,etc.

(HandlingofR32issimilartoR410A.)

CAUTION

1.Installation(Space)

• Thattheinstallationofpipe-workshallbekepttoaminimum.

• Thatpipe-workshallbeprotectedfromphysicaldamage.

• Thatcompliancewithnationalgasregulationsshallbeobserved.

• Thatmechanicalconnectionsshallbeaccessibleformaintenancepurposes.

• Incasesthatrequiremechanicalventilation,ventilationopeningsshallbekept

clearofobstruction.

• Whendisposingoftheproductisused,bebasedonnationalregulations,properly

processed.

2.Servicing

2-1.Servicepersonnel

• Anypersonwhoisinvolvedwithworkingonorbreakingintoarefrigerantcircuit

shouldholdacurrentvalidcerticatefromanindustry-accreditedassessment

authority,whichauthorizestheircompetencetohandlerefrigerantssafelyinac-

cordancewithanindustryrecognisedassessmentspecication.

• Servicingshallonlybeperformedasrecommendedbytheequipmentmanufac-

turer.Maintenanceandrepairrequiringtheassistanceofotherskilledpersonnel

shallbecarriedoutunderthesupervisionofthepersoncompetentintheuseof

ammablerefrigerants.

• Servicingshallbeperformedonlyasrecommendedbythemanufacturer.

2-2.Work

• Priortobeginningworkonsystemscontainingammablerefrigerants,safety

checksarenecessarytoensurethattheriskofignitionisminimised.Forrepairto

therefrigeratingsystem,theprecautionsin2-2to2-8shallbecompliedwithprior

toconductingworkonthesystem.

• Workshallbeundertakenunderacontrolledproceduresoastominimizetherisk

ofaammablegasorvapourbeingpresentwhiletheworkisbeingperformed.

• Allmaintenancesta󰀨andothersworkinginthelocalareashallbeinstructedonthe

natureofworkbeingcarriedout.

• Workinconnedspacesshallbeavoided.

• Theareaaroundtheworkspaceshallbesectionedo󰀨.

• Ensurethattheconditionswithintheareahavebeenmadesafebycontrolofam-

mablematerial.

2-3.Checkingforpresenceofrefrigerant

• Theareashallbecheckedwithanappropriaterefrigerantdetectorpriortoanddur-

ingwork,toensurethetechnicianisawareofpotentiallyammableatmospheres.

• Ensurethattheleakdetectionequipmentbeingusedissuitableforusewitham-

mablerefrigerants,i.e.nonsparking,adequatelysealedorintrinsicallysafe.

2-4.Presenceofreextinguisher

• Ifanyhotworkistobeconductedontherefrigerationequipmentoranyassociated

parts,appropriatereextinguishingequipmentshallbeavailableathand.

• HaveadrypowderorCO2reextinguisheradjacenttothechargingarea.

2-5.Noignitionsources

• Nopersoncarryingoutworkinrelationtoarefrigerationsystemwhichinvolves

exposinganypipeworkthatcontainsorhascontainedammablerefrigerantshall

useanysourcesofignitioninsuchamannerthatitmayleadtotheriskofreor

explosion.

• Allpossibleignitionsources,includingcigarettesmoking,shouldbekeptsu󰀩cient-

lyfarawayfromthesiteofinstallation,repairing,removinganddisposal,during

whichammablerefrigerantcanpossiblybereleasedtothesurroundingspace.

• Priortoworktakingplace,theareaaroundtheequipmentistobesurveyedto

makesurethattherearenoammablehazardsorignitionrisks.“NoSmoking”

signsshallbedisplayed.

2-6.Ventilatedarea

• Ensurethattheareaisintheopenorthatitisadequatelyventilatedbeforebreak-

ingintothesystemorconductinganyhotwork.

• Adegreeofventilationshallcontinueduringtheperiodthattheworkiscarriedout.

• Theventilationshouldsafelydisperseanyreleasedrefrigerantandpreferably

expelitexternallyintotheatmosphere.

Produkt Specifikationer

Mærke:	Fujitsu
Kategori:	Aircondition
Model:	AOYG45KRTA

Har du brug for hjælp?

Hvis du har brug for hjælp til Fujitsu AOYG45KRTA stil et spørgsmål nedenfor, og andre brugere vil svare dig

Dit navn*

Din email*

Skriv dit spørgsmål her

Aircondition Fujitsu Manualer

Fujitsu AIRSTAGE AJY040LBLDH Manual

11 Januar 2025

Fujitsu ARXP014HLAH Manual

8 Januar 2025

Fujitsu ARXD009HLAH Manual

8 Januar 2025

Fujitsu AUXN014HLAH Manual

8 Januar 2025

Fujitsu ARXP009HLAH Manual

8 Januar 2025

Fujitsu ARXD005HLAH Manual

8 Januar 2025

Fujitsu ARXD007HLAH Manual

8 Januar 2025

Fujitsu ARXD004HLAH Manual

8 Januar 2025

Fujitsu ARXD014HLAH Manual

8 Januar 2025

Fujitsu ARXD024HLAH Manual

8 Januar 2025

Aircondition Manualer

Nyeste Aircondition Manualer

Eurom Airflow LED Cordless Manual

13 Juni 2025

Daikin FXNQ63A2VEB Manual

9 April 2025

Daikin FXNQ20A2VEB Manual

9 April 2025

ARCTIC WIND 3AWH12000A Manual

4 Marts 2025

Daitsu AUD-30K-DB Manual

28 Februar 2025

Daitsu AUD 36K DB Manual

28 Februar 2025

Daitsu AUD 48K DB Manual

28 Februar 2025

Daitsu AUD 60TK DB Manual

28 Februar 2025

Daitsu AUD 42K DB Manual

28 Februar 2025

Daitsu AUD 48TK DB Manual

28 Februar 2025