Polaris PB4-60 Manual

Polaris Pomp PB4-60

Læs gratis den danske manual til Polaris PB4-60 (40 sider) i kategorien Pomp. Denne vejledning er vurderet som hjælpsom af 28 personer og har en gennemsnitlig bedømmelse på 4.3 stjerner ud af 14.5 anmeldelser. Har du et spørgsmål om Polaris PB4-60, eller vil du spørge andre brugere om produktet?

Download PDF

Side 1/40

FOR YOUR SAFETY - This product must be installed and serviced by a contractor who is licensed and qualied

in pool equipment by the jurisdiction in which the product will be installed, where such state or local requirements

exist. In the event no such state or local requirement exists, the maintainer must be a professional with sufcient

experience in pool equipment installation and maintenance, so that all of the instructions in this manual can be

followed exactly. Improper installation and/or operation can create dangerous electrical hazards, which can cause

high voltages to run through the electrical system. Before installing this product, read and follow all warning

notices and instructions that accompany this product. Failure to follow warning notices and instructions may result

in property damage, personal injury, or death. Improper installation and/or operation will void the warranty.

If these instructions are not followed exactly, a re or explosion may result, causing property damage, personal

injury, or death.

ATTENTION INSTALLER: This manual contains important information about the installation,

operation and safe use of this product. This information should be given to the owner/operator of

this equipment.

WARNING

H0344400 REVD

Pressure Cleaner

Booster Pump

Installation and

Operation Manual

For Polaris PB4-60 Booster Pumps with Serial Numbers beginning with "PB"

and a manufacturing date on or after Dec 1, 2011.

ENGLISH | FRANÇAIS

Page 2 ENGLISH Polaris® PB4-60 Booster Pump | Installation and Operation Manual

Table of Contents

Section 1. IMPORTANT SAFETY INSTRUC-

TIONS 3 .............................................

1.1 Safety Instructions ............................................ 3

1.2 Pool Pump Suction Entrapment

Prevention Guidelines ....................................... 5

Section 2. General Description 6 ......................

2.1 Introduction ....................................................... 6

2.2 Description ........................................................ 6

2.3 Preparation ....................................................... 6

Section 3. Installation 6 .....................................

3.1 Electrical Installation ......................................... 6

3.1.1 Voltage Checks 6 .....................................

3.1.2 Bonding and Grounding 6 .........................

3.2 Electrical ........................................................... 6

3.2.1 Electrical Wiring 7 .....................................

3.3 Plumbing ........................................................... 7

3.3.1 Requirements ........................................ 7

3.3.2 Pipe Sizing 8 .............................................

3.3.3 Pump Location 8 .......................................

3.3.4 Install the Pump 9 .....................................

3.3.5 Installation Recommendations 9 ..............

3.3.6 Check the Water Flow 9 ...........................

3.3.7 Conduct Pressure Test .......................... 10

Section 4. Operation 10 .......................................

4.1 Start-up ............................................................. 10

Section 5. Maintenance .................................. 11

5.1 Winterizing the Pump ........................................ 11

Section 6. Troubleshooting and Repair 12 ........

6.1 Troubleshooting ................................................ 12

6.2 Service Technician Maintenance ...................... 13

6.2.1 Blocked Impeller 13 ....................................

6.2.2 Impeller Removal 13 ...................................

6.2.3 Impeller Replacement 14 ............................

6.2.4 Mechanical Seal Replacement 14 ..............

6.2.5 Motor Replacement 15 ..............................

Section 7. Product Specications and Techni-

cal Data 16 ..........................................

7.1 Replacement Parts List ..................................... 16

7.2 Polaris PB4-60 Booster Pump Exploded View . 16

7.3 Pump Dimensions ............................................. 17

7.4 Visual Identication of the New Polaris PB4-60

Booster Pump ................................................... 18

DATE OF INSTALLATION

INSTALLER INFORMATION

INITIAL PRESSURE GAUGE READING (WITH CLEAN FILTER)

PUMP MODEL HORSEPOWER

NOTES:

EQUIPMENT INFORMATION RECORD

Produkt Specifikationer

Mærke:	Polaris
Kategori:	Pomp
Model:	PB4-60

Har du brug for hjælp?

Hvis du har brug for hjælp til Polaris PB4-60 stil et spørgsmål nedenfor, og andre brugere vil svare dig

Dit navn*

Din email*

Skriv dit spørgsmål her

Pomp Polaris Manualer

Polaris Forza Manual

12 August 2024

Polaris PB4SQ Manual

12 August 2024

Polaris PB4-60 Manual

7 August 2024

Pomp Manualer

Nyeste Pomp Manualer

Little Giant OPWG-29 Manual

1 April 2025

Interphone Air Pump 3000 Manual

1 April 2025

Grundfos UPS 20-60 N 150 Manual

1 April 2025

Grundfos UPS 40-50 FN 250 Manual

1 April 2025

Grundfos MTA 120-280 Manual

1 April 2025

Grundfos DMX 860-5 Manual

1 April 2025

Grundfos UPM4 Manual

1 April 2025

Grundfos DMH 880-10 Manual

1 April 2025

Grundfos MTA 200-280 Manual

1 April 2025

Grundfos MTSE 40-66 Manual

1 April 2025