2023 Fuel EX
1
Safety
WARNING
Tighten hardware properly
Always tighten hardware to the specied torque.
Over-tightening hardware could deform or break the
hardware or components. Under-tightening hardware
could cause hardware or components to become loose.
Either situation could damage the bicycle and result in
injury to the rider.
WARNING
Re-apply threadlocker
All reused-fasteners with a pre-applied threadlocker
must be cleaned with isopropyl alcohol and have new
threadlocker applied before re-assembly. If a threadlock-
er is not applied, the fasteners may loosen, which could
damage the bicycle and result in injury to the rider.
Legend
Apply grease
Do not apply grease
Apply threadlocker
Nm Torque
Hex tool
Torx tool
Drift size
Zip tie
Safety Active Braking
Pivot (ABP)
Rear shock
hardware and
dimensions
Frame guards –
carbon frame
Adjust the
geometry –
headset angle
Adjustable headset Rocker pivot and
seat stay
Adjust the
progression
Frame guards —
aluminium frame
Adjust the
geometry –
seat stay Mino link
Specications
Chainline (1x only)
55mm
Chainring (1x only)
Minimum Maximum
28T Round: 34T
Oval: 32T
Rear brake mount
Minimum Maximum
180mm, direct mount Adaptable to 203mm
Maximum tire size
Notice: Measurements of actual tires may vary. Always
verify there is sufcient clearance between the tire and
the frame. Impro per tire size could dama ge the bicycle
frame. Trek recommends 6mm clearance above and on
the sides of the tire.
Wheel set Maximum tire size
29" 29" x 2.5"
27.5" (XS and S frame) 27.5" x 2.5"
Bottom bracket /ISCG tabs
Seat post
WARNING
Always follow the seatpost manufacturer’s minimum
insertion recomme ndation. Failure to follow the recom
mendation could cause damage to the seatpost and
result in injury to the rider.
Measurement
Maximum
insertion
Frame Carbon
S (27.9” and
29” wheels) 225mm
Seat tube inside diame ter 34.9
Seat tube post clamp
outer diameter 39.5
Fork
WARNING
Exceeding the recommended ma ximum fork length co
damage the bicycle and result in injury to the rider.
Travel
Sag
Axle to Crown
Dérailleur hanger Main pivot and
chain stay
Cable routing Down tube storage Specications
Copyright 2022 Trek Bicycle Corporation All Rights Reserved
