Wilbur Curtis TCC1C Manual

Wilbur Curtis Ikke kategoriseret TCC1C

Læs gratis den danske manual til Wilbur Curtis TCC1C (12 sider) i kategorien Ikke kategoriseret. Denne vejledning er vurderet som hjælpsom af 8 personer og har en gennemsnitlig bedømmelse på 4.5 stjerner ud af 4.5 anmeldelser. Har du et spørgsmål om Wilbur Curtis TCC1C, eller vil du spørge andre brugere om produktet?

Download PDF
Side 1/12
NSF International requires the following water connection:
1. A quick disconnect or additional coiled tubing (at least 2x the depth of the unit) so that the machine
can be moved for cleaning underneath.
2. Thisequipmentistobeinstalledwithadequatebackowprotectiontocomplywithapplicable
federal, state and local codes..
3. Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshallbesized,
installed and maintained in accordance with federal, state, and local codes.
1
Important Safeguards/Symbols
Service Manual, TCC
Thisapplianceisdesignedforcommercialuse.Anyservicingotherthancleaningandmaintenance
shouldbeperformedbyanauthorizedWilburCurtisservicecenter.
•DoNOTimmersetheunitinwateroranyotherliquid
•Nevercleanwithscouringpowders,bleachorharshchemicals.
Symbols:
WARNINGS – To help avoid personal injury Important Notes/Cautions
Sanitation Requirements
Curtis TCC Units are Factory Pre-Set and Ready to Go… Right out of the Box.
Generallytherewillneverbeareasontochangefactorysettings.However,shouldyouneedto
makeslightadjustmentstomeetyourteaneeds,adjustmentinstructionsareprovidedlaterinthis
manual.
SystemRequirements:
•WaterSource30–90PSI(MinimumFlowRateof1GPM).Ifincomingwatersupplyisgreater
than90PSI,additionalregulationisrequiredtomeettherange.
•Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshallbe
sized,installedandmaintainedinaccordancewithfederal,state,andlocalcodes.
SETUP STEPS
Theunitshouldbelevel(lefttorightandfronttoback),locatedonasolidcountertop.Connecta
waterlinefromthewaterltertotheTCCserver.NOTE:Sometypeofwaterltrationdevicemust
beusedtomaintainatrouble-freeoperation.(Inareaswithextremelyhardwater,wesuggestthat
asedimentaryandtaste&odorlterbeinstalled.)Thiswillprolongthelifeofyoursystemand
enhanceteaquality.
INSTALLATION
1.Removedispenserfromcarton.
2.Runawaterlinetotheinletttingbehindthedispenser.Flushthenewwater-
line to remove foreign particles.
3.Connecta¼”aredexibleorcopperwaterlinetothemalettingontheback
of the dispenser.
4.Locatethewatersupplyvalvebehindtheunittoverifypositionisturnedon.
CAUTION:Werecommendedthatthewatersupplyvalve,behindunit,beturnedoffduring
non-business hours.
Wilbur Curtis Company, inC.
ModelsIncluded
•TCC1
•TCC2
•TCC3
NOTE:Watersource
pressure must be a
minimumof30PSI
pressure at all times
toinsurethequalityof
the of the product.
5.CleanouttheteaconcentratesystembeforeusingtheTCCserver.UseaBag-in-Box
stylecleaningsolutiontosimplifythecleaningprocedure.AcleanerlikeBevClean
beveragelinecleanercomesina3gallonbag-in-boxthatconnectsdirectlytoyour
bag-in-boxsystemforlinecleaning(http://bevclean.com).
a.Removethequickdisconnectfromtheteaconcentratebag.
b.PlacetheBIBcleanercontainernexttotheTCCteadispenser.Pullthespout
fromthecleanerboxthroughthemarkedarea.Removethecleartravelcapfrom
spout.Don’tworryaboutcleanerspillingwhenthecapisremoved.Thecaphas
an internal seal.
c. SnaptheQCDbagconnectorontothebagspout.
OFF
ON
ISO 9001:2008 REGIS-
TERED
WILBUR CURTIS CO., INC.
6913 West Acco Street
Montebello, CA 90640-5403
For the latest information go
to www.wilburcurtis.com
Tel: 800-421-6150
Fax: 323-837-2410
2
7. Carefullyliftthebagandsetthebagintothedispenser.
8. Resttubingontopofthebag.Routetubingtooppositeproductintake
holeonoorofdispenser(seeillustration,left).
9. Replacethetopcover.
10. Dispensebeveragefromfaucetuntildarkerproductstartstoappear(~5
seconds).
11. TheTCCserverisnowreadytodispensetea.
3. Pullofftheshipping
cap that covers the
spout on the bag.
4. PlacetheQCDnextto
the spout.
5. SlideQCDsideways,
over the bag spout.
QCDsnapsinplace.
6. PushQCDplungerinto
bag spout until plunger
topisushwithtopof
QCD.A“click”willbe
heardwhenitisfully
inserted.
LOAD PRODUCT
Bag-In-Box
1.PlaceateaconcentratebagonthecounternexttotheTCCdispenser.
2. RemovethetopcoverfromtheTCCdispenserandpulloutthehosewiththeQCD
bag connector.
d. Graspingthebagconnector(asshowninLoadProduct,step6),pushtheslidingprobeallthewayintothe
bagspout.A“click”willbeheardwhenitisfullyinserted.
e. Oncethecleaningsolutionboxisconnected,openthedispensingvalveonthedispenserandrunliquid
throughthevalveuntilthesanitizer(clearliquid)isdetected.Thedispensinglineisnowclean.
f. Disengagethebagconnectorbysnappingtheconnectorprobeoutandremovetheconnectorfromthespout.
g. ReattachtheteaconcentrateBIB.
h. Opendispensingvalveondispenseruntilteaowsfreely.
WATER PRESSURE AND MIXING VALVE
Thepressureregulatorshouldrarelybechanged.Primarytaste/brixadjust-
mentsshouldbedoneviathemixingvalvebyturningtherodandtastingthe
nishedproduct.98%ofavoradjustmentsshouldbedoneinthismanner.
The purpose of the regulator is to provide uniform water pressure so the venturi-
stylemixingdevicecanproduceastableanduniformblendofconcentrateand
waterandalsotoprotectthehydraulicsofthedispensingunitfrom“linepres-
sure”.Itisnottheprimaryadjustmentforthebrixlevel.Fromourtesting,ithas
beenshownthatexactPSIonthegagedoesnotdirectlycorrelatetoabrixlevel
from unit to unit and from installation location to installation location.
Secondarily,iftheprimaryadjustmentdoesn’tprovidetheidealbrixlevel,call
CurtisCareforinstructionsonhowtoadjusttheregulator.Asarule,verylittletasteadjust-
ment is achieved via the pressure regulator.
CAUTION: Do Not Exceed 25 psi (static). Equipmentfailureorleakagewill
result.

Produkt Specifikationer

Mærke: Wilbur Curtis
Kategori: Ikke kategoriseret
Model: TCC1C

Har du brug for hjælp?

Hvis du har brug for hjælp til Wilbur Curtis TCC1C stil et spørgsmål nedenfor, og andre brugere vil svare dig


Ikke kategoriseret Wilbur Curtis Manualer

Wilbur Curtis

Wilbur Curtis G4STB Manual

28 September 2025
Wilbur Curtis

Wilbur Curtis WB5NLB Manual

28 September 2025
Wilbur Curtis

Wilbur Curtis G4TB Manual

28 September 2025
Wilbur Curtis

Wilbur Curtis TC-3S Manual

28 September 2025
Wilbur Curtis

Wilbur Curtis TCC2 Manual

28 September 2025
Wilbur Curtis

Wilbur Curtis TCN Manual

28 September 2025
Wilbur Curtis

Wilbur Curtis GEM-3 Manual

28 September 2025
Wilbur Curtis

Wilbur Curtis TCC1C Manual

28 September 2025
Wilbur Curtis

Wilbur Curtis TCC3 Manual

28 September 2025
Wilbur Curtis

Wilbur Curtis SW-1 Manual

25 August 2025

Ikke kategoriseret Manualer

Nyeste Ikke kategoriseret Manualer

Vestil

Vestil AHTD-3672 Manual

8 Oktober 2025
Vestil

Vestil ZLTT-4472-2-48 Manual

8 Oktober 2025
Vestil

Vestil OLA-2-42-DLX Manual

8 Oktober 2025
Joy-It

Joy-It SBC-Buck01 Manual

8 Oktober 2025
Ikan

Ikan HomeStream HS-USB-MIC Manual

8 Oktober 2025
Turbo Air

Turbo Air TCA381AE Manual

8 Oktober 2025
Panduit

Panduit CEG-05X2 Manual

8 Oktober 2025
Vestil

Vestil LO-DC-MR Manual

8 Oktober 2025
Vestil

Vestil LLCB-202058 Manual

8 Oktober 2025
Axxess

Axxess AXDI-6524 Manual

8 Oktober 2025